Serial Hybrid Kinetic Energy Storage Systems - SHyKESS

Lead Research Organisation: University of Nottingham
Department Name: Faculty of Engineering

Abstract

This proposal is about energy storage of a very specific kind to support the electricity grid. The case for energy storage is extremely strong at the moment as we decarbonise electricity generation. The world has reached the very interesting point where the cheapest electricity actually comes from wind and sunshine but these generation forms unfortunately produce electricity only when the primary resource is available - i.e. wind turbines make electricity only when the wind blows and (most) solar power can only make electricity when the sun is shining. So long as these renewables comprise only a small proportion of all of our generation, the intermittency of wind and solar power is no problem at all - because we can control the generation being obtained from coal-fired and gas-fired power stations. However, if we are to generate high fractions of all of our electricity from renewables, we will need to be able to store large amounts of energy.

Now, there are many different ways to store energy. No one form is a solution for all of our needs. Energy storage has to developed to be suitable over a large range of timescales and a large range of sizes. Each system being developed has its own particular set of advantages and disadvantages. Cost is extremely important in all cases: energy storage is extremely expensive. Most people do not realise that even with the best commercial offerings at present, the ratio between the cost of an energy store and the value of the energy that it contains is typically 1000:1. Lifetime is also extremely important. If a given energy store has a lifetime that is only, say, 5000 cycles, then that energy store must be replaced after 5000 cycles and the cost that it will add to the energy that has passed through it will typically be ~20% on this basis. Turnaround efficiency is also important, if you lose 20% of all of the energy that comes into the store, this adds a further cost that could be anything up to 20% (but would usually be more like 10% because the input energy is usually much less valuable than the output).

This proposal sets out to examine a system that appears to offer energy storage over a range of timescales between milli-seconds and tens of hours. The system comprises two distinct energy stores connected in a "serial" fashion in the sense that there is only one output to the grid. One of these energy stores is a very large flywheel. The second is typically a compressed air store but it may also be a high-head pumped hydro store or a pumped-thermal store or an energy store based on liquefied air. The connection to the grid is via a large synchronous generator. These systems are suitable only at medium-to-large scale - powers above 50MW and energy storage capacities in the order of 250MWh and above. They are not suited for urban locations. For those (many) situations where they are suited, these systems appear to offer the potential for extremely high performance at very competitive costs.

Most importantly and also most distinctively, the combination of the flywheel and the rotor of a synchronous machine endows these stores with substantial amounts of "real inertia". Inertia sounds like a bad thing but in the context of electrical power systems it is an extremely good thing and it is present in all of the spinning rotors in steam-turbine-driven power generation. As we move away from generation using coal, oil and gas, we are switching off these big rotating generators and we are losing inertia that was previously present as a free service. With lower inertia, the system responds more suddenly to changes in load or generation. If we allow too much inertia to disappear from our electricity system, we become very vulnerable to uncontrolled system shutdowns from either unexpected weather fluctuations, glitches in communications networks or from mischievous cyber-attacks which can use the system sensitivity to trigger disproportionately large events from relatively small actions.

Planned Impact

SHyKESS systems could become a single cost-effective energy storage solution operating over a range of timescales from milli-seconds to tens of hours. They marry a fast and highly robust energy storage form (spinning inertia) with unlimited life and superb efficiency (~99%) together with slower secondary energy storage form having lower costs but also lower efficiency (~60% - ~75%). Expected marginal costs per unit of energy storage capacity are ~£250/kWh for the fast storage and <£25/kWh (sometimes much less) for the secondary storage. SHyKESS systems have natural lower-limits of scale: power ratings >50MW, storage durations of tens of minutes for the KE storage and storage durations of a few tens of hours for the secondary store. There are many locations at nodes of the UK electricity transmission and distribution systems where such systems could be installed.

The main overall impact of this development will be that higher penetrations of renewables will be affordable in both the UK and many other regions than would otherwise be the case. Ultimately, this will have a real effect on averting some substantial CO2 release and making reliable electricity systems affordable in many regions where it would not otherwise be so. Obviously, numerous other energy storage propositions would make similar claims but the SHyKESS concept has some real and verifiable attractions over most competing systems:

* Virtually any form of thermo-mechanical energy storage can be integrated directly as the secondary energy store in a SHyKESS system. Specifically, pumped-hydro energy storage, compressed air energy storage, pumped-thermal energy storage and liquid-air energy storage are all attractive candidates. Thus, the real question in these cases is not "SHyKESS or ~ ?" so much as "SHyKESS with ~ ?".

* The SHyKESS design is such that it introduces real inertia back into the system - replenishing the inertia continually being lost as large turbo-alternators are being retired in favour of renewable generation.

* Real inertia is un-hackable . Cyber-security is emerging as one of the primary concerns of utilities and grids.

* Real inertia has no dependency on the integrity of any sensing or communications pathway to act and thus it has potential to be intrinsically very robust.

* Real inertia is always stabilising. Simulated inertia realised via active control can be destabilising at grid level.

* The SHyKESS systems intrinsically deliver the phase-balancing and reactive power compensation functionalities presently provided by "STATCOMs" at zero marginal cost.

* The primary energy store (the flywheel element) has effectively infinite life. An all-steel flywheel rotor of any design would be expected to last at least ten million (107) complete cycles. Since no complete discharge of a SHyKESS flywheel would occur in <5 minutes, this indicates a rotor service lifetime in excess of 200 years. Some elements of SHyKESS systems will certainly require inspection (perhaps annually) to verify continued fitness for purpose. The secondary energy store will naturally see far fewer cycles than the primary store. Most of the natural candidates for secondary energy stores in these systems also have natural lifetimes exceeding many tens of thousands of cycles. Thus, these systems are extremely well suited to long-term infrastructure investments.

* SHyKESS systems are especially well suited to development and manufacture in the UK. The UK has excellent indigenous expertise in hydraulic machinery, electrical machines and realising vacuum vessels. Moreover, SHyKESS systems require no exotic materials whose prices might be volatile in the future for the UK (Lithium, Vanadium, Neodymium, Dysprosium, Palladium, Gallium etc.)
 
Description It is cost-effective to introduce grid inertia back into the grid using mechanical flywheels connected directly to synchronous machines (the same machines that serve in large power stations all over the world) and there are major advantages to doing this. In particular: (1) the system is highly robust and relatively impenetrable to cyber-infererence, (2) the synchronous machines provide secondary benefits of fault currents and power factor correction that are not generated by the power electronics sets and (3) the synchronous machines eat-up harmonic distortion produced elsewhere in the grid so that the voltage waveforms everywhere are nice and smooth.
Exploitation Route We have proposed to National Grid that a pilot study should be launched under the "Network Infrastructure Competition" or similar. Ultimately this study would lead to the installation and operation of a nominal 50MW, 10MWh system which could reproduce 10% of the inertia that was present on the grid in year 2000. We expect that this project would cost no more than £15M and would justify its own cost in less than 2 years. The study would be divided into three phases with phases 1 and 2 costing <£450k.

For reasons that are complex to explain, the systems of interest have a natural size that involve a flywheel of ~750tons spinning at 1500rpm.
Sectors Energy

 
Description This grant emphasised the importance of real inertia. Four distinct one-day workshops have been organised and three have already run (the fourth will take place in June, 2023) that bring together all important players in the area of grid inertia. Now hosted by EPRI, these workshops have become a central communication line for the grid inertia community and the workshops are attended by representatives of utilities and transmission system operators around the world. We did progress semi-commercial discussions about the actual deployment of the "SHyKESS" system at the sites of closing-down coal-fired power stations and some of these discussions remain alive. Commercial difficulties on the part of the then-intended industrial partner suspended those discussions at least temporarily but there remains prospect to resurrect those.
Sector Energy
Impact Types Economic

 
Description Contributed to Future Energy Scenarios (National Grid)
Geographic Reach National 
Policy Influence Type Contribution to a national consultation/review
 
Description Event Run: "Grid Inertia: Current perceptions and future directions of travel". Feb 24, 2020
Geographic Reach Europe 
Policy Influence Type Influenced training of practitioners or researchers
URL https://app.researchfish.com/portfolio/0/influence-on-policy-and-practice?action=add&zone=portfolio&...
 
Company Name CHEESECAKE ENERGY LIMITED 
Description Cheesecake Energy Ltd. (CEL) is developing and selling a medium-scale (150kW), medium-duration (5hrs - 12hrs of discharge time) energy storage system. The system stores energy in the combined forms of pressurised air (34%) and heat (66%). The system uses modified ex-service truck engines to become compressor/expander machines and uses its own unique valve-actuation system to enable the same machine to serve as compressor (for charging) and as expander (for discharging). The system includes significant amounts of natural inertia but also has the capability to include more based on the findings from the SHyKESS research programme. 
Year Established 2016 
Impact Impacts are only just beginning but CEL has secured a contract with Colchester Amphora to support a business part and it will account for several millions of pounds of cost saving on this site alone. It is being explored seriously for supporting EV charging stations.
 
Description One-day workshop:: Grid Inertia 2020: Current perceptions and future directions. 
Form Of Engagement Activity Participation in an activity, workshop or similar
Part Of Official Scheme? No
Geographic Reach National
Primary Audience Industry/Business
Results and Impact Grid inertia is the first line of defence in helping the electricity grid to balance supply and demand. Neither wind turbines nor photo-voltaic panels endow the grid naturally with inertia and as the penetration of renewables increases dramatically (as it will continue to do), we are approaching a crisis of grid non-robustness. The major blackout of August 8, 2019 might have been averted if there had been more grid inertia on the system.

This event brought together specialists in the area to discuss the present state of technology, policy and markets. The event was thoroughly appreciated by all attendees - to the extent that there is an obvious need for this event to become annual. The 2021 event is now organised for May 11, 2021.
Year(s) Of Engagement Activity 2020
URL http://www.era.ac.uk/Grid-Inertia